Chevrolet Chevy Van Questions Maintenance & Repair

1988 Chevy G20 PS Gearbox - Pitman Seal

I have a leaking pitman seal on my steering gear. It started gradual but it definitely needs to be fixed now. The Haynes manual details how to change this without removing the box from the vehicle but...

1990 G20 Headlights Flash Off And On

When I turn the headlights on, only the high beams work and then they start flashing. You can see the green driving light flash off and on and at the same time the actual headlights are flashing off a...

1989 Chevy G20 Van

i have a 1989 chevy van it shut off with no oil in it . when i added oil in it , it still would not start. i need to know why

Will A 93' Full Size Hood Fit A 98' Full Size?

My Van Shut Off Without Any Oil In It . When I Added Oil To The Van It Woul...

1987 Chevy G-20 Van

1987 chevy 3/4 ton 5.7 w/ 350 replaced fuel pump, fuel filter, pump relay switch, ignition module,dist. cap, plug and wires, temp. sensor switch, ignition coil, alternator and battery starts , runs f...

CAN'T ORDER LOWER CONTROL ARM G20 1984 CHEVY WHY?

CAN FIND BUSHINGS. NO LOWER CONTROL ARM. ARE THEY THE SAME AS A PICKUP?

G30 Brakes

93 chevy g30 makes a rattling noise from the front brakes i was told this is a common prom with the bendix slide type calipers what can fix the nose problem

94 Van Does Not Idle Well No Pickup ?

van shuts off when tight turns no pickupor excelleration on highway any suggestions?

Bleeding Breaks On 3500 Express Van

Replace the break line from the distribution module under the fan by drivers seat and now cannot get any fluid thru the line. Using a vaccum pump or just pressing the pedal with the engine off or on. ...

Can't Fill My Fuel Tank

Every gas pump I try shut off very prematurely no matter which way I hold the pump handle to get as much venting as possible. I get squeeze off a nickel of gas before shutoff. I checked the main ven...

Where Is The Fuel Filter

Brakes On 93 Chevy Van Locking Up

Brakes on 93 chevy van locking up. Changed rotors, brake pads and new master cylinder. They still locking. Already checked lines for crimps. Someone said that maybe ABS box. Can anyone help?

Where Is The Fuel Filter Located On A 1995 G30?

Exhaust

My van with 85K miles will not pass emissions inspection. The inspector told me thats its the catilytic converter. Thinking of going with a Magnaflow. Any thoughts?

Ignition System Failure

I have an 81 G20 3/4 ton that I just swapped engines in. The other day while taking to on a test run, some exposed wires at the starter grounded out, creating a large spark and killing the engine. N...

1992 Chevy G20 Van 350 5.7L TBI

Won't Crank, All Panel lights on, used to crank after 5 tries of turning the key, now it wont

Replaced Fuel Pump And Relay And Still Not Getting Fuel To Engine

What Is The Best Way To Get At The Distributor, Spark Plugs, And Ignition W...

I was looking to tune up my 1993 G30 Cargo Van by replacing the distrubtor, plugs and wires, do an oil change, etc etc as I just bought it used. What is the best way to get at the Distributor, Spark ...

2002 1500 Express Rear Brake Replacement

I am replacing the rear brake shoes & cannot remove the drums. According to the service manual I must "pin" the parkig brake ato adjust control. I Have never done this in the past. Is it necessary? Or...