2005 Kia Sorento overheating

140

Asked by Dec 02, 2015 at 10:00 PM about the 2005 Kia Sorento LX 4WD

Question type: Maintenance & Repair

Replaced Fan unit.  Fans working but still overheats or at least the gauge starts climbing.  Top hose is warm and bottom hose is cool.

12 Answers

186,535

Sounds like a no flow problem, could be a thermostat or even a restricted radiator, get it checked before you blow a head gasket, Kia's are known for it, just a little bit of excess heat and they blow. HTH

5 people found this helpful.
140

One day was fine.....next day fans weren't working. replaced fans and still not working.....fooled with relays got both fans working but still overheating. Could the problems be related or just coincidence. Hoping it is thermostat.

7 people found this helpful.
186,535

The fan sensor has to detect coolant temp to close the relay for the fans to operate, so that is what they have in common, I would be more concerned about the upper hose is hot but the lower is cold, it should be at least warm, I would get one of those laser temp detectors and measure the temps as you go down the radiator, it should drop gradually as you go down the radiator, not just drop all at once past a certain spot. HTH

1 people found this helpful.
140

Ok.....removed thermostat and running open without thermostat. Both hoses about same temp....but gauge still climbs to hot. Turned heater on while showing hot and there was no heat....until I revved engine then heater started working fine but the gauge still showed hot. Not sure where to check next.

3 people found this helpful.
186,535

That sounds like you have an air pocket in the cooling system, you may have to get the top of the radiator higher to get the air out, it probably got there when you pulled out the thermostat. Then see if the temp goes down, if not then check to see if it is actually overheating and not a gauge malfunction.

2 people found this helpful.
Best Answer Mark helpful
140

I have no way of measuring actual engine temp. I am limited to process of elimination. I am pretty much down to water pump or heat sensor and have no idea how to eliminate either one. Is it even possible for a water pump to be bad but still proficient enough to deliver hot water to the heater core?

2 people found this helpful.
140

Latest clue.....After allowing sufficient time to cool, went out and started. Not warm enough to provide heat thru the heater yet gauge was starting at just below center. Heats up to just below max hot. Does this sound like a bad gauge??? Done for the night gonna re check in the morning. Ambient temps suppose to drop near 40 deg. F tonight. If gauge not bottomed out in morning I'll have my answer. Will post answer when I get one.

2 people found this helpful.
186,535

Ok I'll be watching.

2 people found this helpful.
140

OK. Soooo.....after all that it turns out the gauge is bad. It Normally runs just an eighth above center. But because the gauge reads 1/4 when it should be dead cold it is starting out 1/4 so when it goes up approx. 5/8 it now runs just 1/8 below red. In conclusion it is not running hot at all. The gain is still 5/8 of the gauge. Hope that makes sense. Thanks for the help Tennishoes. Gonna leave the gauge for another day. I'm too fat and old to crawl under the dash to remove the "screw holding the bottom of the dash. I sure miss the simplicity of the pre 70's cars when it comes to working on them.

186,535

Especially in a Kia, not much room to begin with, I don't know if there is a spot for it but have you thought about a aftermarket gauge that you put in a pod for the door pillar or someplace on or under the dash where you can see it, just a thought.

140

Yeh thought about doing that. gonna have to go shopping.....and of course the heat sensor is not all that easy to get to on the side of the heads.....one of the reasons I was trying not to go to the sensor til last ditch effort. Always taking the path of least resistance is not necessarily the best route to go. Spent a lot of money just to determine the gauge was bad. Such is the life of a DIY mechanic.

186,535

Ok good luck on your search.

Your Answer:

Sorento

Looking for a Used Sorento in your area?

CarGurus has 3,221 nationwide Sorento listings and the tools to find you a great deal.

Postal Code:

Kia Sorento Experts

  • #1
    5240
    Reputation
    870
  • #2
    COMETGUY61
    Reputation
    780
  • #3
    roc622
    Reputation
    750
View All

Find great deals from top-rated dealersTM

Search

Related Models For Sale

Used Hyundai Santa Fe
33 Great Deals out of 3,229 listings starting at $2,499
Used Kia Sportage
48 Great Deals out of 2,225 listings starting at $2,900
Used Toyota Highlander
23 Great Deals out of 1,535 listings starting at $3,980
Used Ford Explorer
57 Great Deals out of 1,905 listings starting at $3,000
Used Honda CR-V
114 Great Deals out of 6,449 listings starting at $3,488
Used Chevrolet Equinox
81 Great Deals out of 5,408 listings starting at $458
Used Toyota RAV4
83 Great Deals out of 4,586 listings starting at $3,888
Used Honda Pilot
40 Great Deals out of 1,231 listings starting at $2,500
Used Hyundai Tucson
75 Great Deals out of 4,201 listings starting at $1,995
Used Ford Escape
144 Great Deals out of 7,713 listings starting at $2,495
Used Jeep Grand Cherokee
70 Great Deals out of 4,376 listings starting at $3,980

Used Cars for Sale

2019 Kia Sorento For Sale
16 Great Deals out of 1,158 listings starting at $20,995
2018 Kia Sorento For Sale
4 Great Deals out of 190 listings starting at $18,614
2017 Kia Sorento For Sale
196 listings starting at $16,995
2016 Kia Sorento For Sale
17 Great Deals out of 391 listings starting at $13,787
2015 Kia Sorento For Sale
12 Great Deals out of 212 listings starting at $9,995

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.