02 ford expedition cranks but wont start.

5

Asked by ford54pos Sep 07, 2016 at 07:31 PM about the 2002 Ford Expedition XLT 4WD

Question type: Maintenance & Repair

I had to rebuild my 5.4 POS triton motor in my 02 ford expedition. Now it wont start. I have replaced the crank and cam position sensors, I tested all the fuses and fuel relay and pcm relay and pcm diode is new.  I replaced all the wires on the engine wire harness and rang them all out and tested resistance- got .2 ohms. I tested fuel cut off switch and theres power past the switch. I get 12 volts at every coil pack and injector. the fuel pump comes on for 1.5 seconds when turned on. when its cranked over I only get 1 pulse flash from noid light at injector 1. if turned off then on again it will flash 1 time again. no pulses to coil packs. I cleaned the ground connections and all are tight. I tested the fuel pressure at the shrader valve on the fuel rail and got no pressure but the instructions on the fuel guage says the motor must be running to read any pressure??  I'm lost now and don't know where to look next. when I tried starting fluid it tried to fire for a second but wouldn't start. now even starting fluid wont do anything.   Please help.

3 Answers
4,205

Bender0013 answered 7 years ago

did you put in new timming chain in if so could be out of time when you put back together.

Mark helpful
5

ford54pos answered 7 years ago

complete rebuild and timing marks all lined up perfect. I had another mechanic double checking all the steps. its strange that the fuel pump works (only 2 years old) but I cant get a pressure reading at the fuel rail. the heads and were machined and set at tdc. its a 2 chain system with single overhead cams. the new chains have stamped marks and colored links, its almost impossible to get it wrong. could the injection system be bleeding pressure somewhere and that shuts down the system? Bad or leaky injectors maybe? over the last 2 years Ive had to put over $6000 into it. nearly 80% under the hood is new or rebuilt. book is $4500 so I don't know when to stop and part it out. its so close to running and its in excellent condition.

Mark helpful
10

Edward answered 5 years ago

I know this post is older, but did you ever figure this out? I'm having a similar issues.

1 people found this helpful.
Mark helpful

Your Answer:

Related Questions

  • 02 ford expedition cranks but wont start. 3 Answers

    I had to rebuild my 5.4 POS triton motor in my 02 ford expedition. Now it wont start. I have replaced the crank and cam position sensors, I tested all the fuses and fuel relay and pcm relay and pcm di...

    2002 Ford Expedition XLT 4WD

    -

    Maintenance & Repair

  • 1999 FORD Expedition wont start 4 Answers

    need help my 1999 ford expedition wont start it cranks but wont start. The odometer has dashes all the way across and the theft light isnt blinking. we had though it might of been a theft issue but ...

    1999 Ford Expedition 4 Dr Eddie Bauer 4WD SUV

    -

    Maintenance & Repair

  • 2002 Expedition XLT cranks but won't start. 1 Answer

    2002 Expedition XLT cranks but won't start. Theft light blinking. OBD reads "No Link". Odometer reads -------- Shows gas in tank. Think I hear fuel pump prime with key turned to 1. Took spare down b...

    2002 Ford Expedition XLT

    -

    Maintenance & Repair

  • Why my ford expedition wont start? 1 Answer

    Why my ford expedition wont crank or fire up? I bought new starter and battery.

    2001 Ford Expedition XLT

    -

    Maintenance & Repair

  • 2006 Expedition runs great but wont start after it sits 1 Answer

    runs great but after I try to startt it after few hours wont start...cranks over and ALMOST starts but wont...

    2006 Ford Expedition XLT Sport 4WD

    -

    Maintenance & Repair

Expedition

Looking for a Used Expedition in your area?

CarGurus has 664 nationwide Expedition listings starting at $7,894.

Postal Code:

Shortcuts

Search Ford Expedition Questions

CarGurus Experts

  • #1
    Larry Sturgis
    Reputation
    5,240
  • #2
    T_S_T
    Reputation
    4,540
  • #3
    Gene Arnett
    Reputation
    2,710
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Chevrolet Tahoe
11 Great Deals out of 832 listings starting at $9,980
Used Chevrolet Suburban
7 Great Deals out of 532 listings starting at $10,950
Used Ford Explorer
61 Great Deals out of 2,048 listings starting at $6,990
Used Lincoln Navigator
9 Great Deals out of 310 listings starting at $24,945
Used GMC Yukon
12 Great Deals out of 972 listings starting at $3,000
Used Ford F-150
325 Great Deals out of 13,693 listings starting at $3,800
Used GMC Yukon XL
12 Great Deals out of 726 listings starting at $11,500
Used Toyota Sequoia
4 Great Deals out of 56 listings starting at $19,990
Used Cadillac Escalade
14 Great Deals out of 501 listings starting at $5,931
Used Toyota 4Runner
23 Great Deals out of 545 listings starting at $12,999
Used Honda Pilot
40 Great Deals out of 899 listings starting at $591
Used Ford F-250 Super Duty
24 Great Deals out of 784 listings starting at $4,290
Used Chevrolet Silverado 1500
200 Great Deals out of 8,052 listings starting at $1,500

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.