The a/c compressor clutch stops spinning and a/c quits blowing cold after running for a couple of miles.

Asked by Verona_379 Jun 11, 2013 at 10:21 PM about the 2004 GMC Sierra 1500 2 Dr SLE Standard Cab SB

Question type: Maintenance & Repair

It happens after a\c runs for 25
minutes or more.

1 Answer

60

If it is an older vehicle (>10yr and/or >150k mi) it is very often the air gap on the compressor clutch. On some vehicles this is a 5 minute fix that costs no money as long as you have some basic tools. For safety reasons, I am not going to recommend doing the test as it can be very dangerous. However, if there was some way that the stopped clutch plate could be tapped while stopped and it reengages and starts turning, that is a sure-fire sign of too large of an air gap (it could take a decently strong tap). On my 2006 Sierra all it takes to reduce the gap is to remove one bolt out of the center of the clutch plate (accessible side of the pully). Then after pulling the clutch plate out, inside the center shaft will be a small washer (or a few). You just remove one of the washers (be sure they don't fall out as you remove the clutch plate) and then put it all back together. The air gap will be reduced and your A/C will be working fine again. That being said (VERY IMPORTANT), you need to ensure that after you start the vehicle with the A/C turned off, that the clutch plate is not spinning. It must have a large enough gap to stop rotating when the A/C is turned off or you will burn up your compressor.

6 people found this helpful.

Your Answer:

CarGurus Experts

  • #1
    yetilikesbeer
    Reputation
    12,340
  • #2
    dragonflyoffshore
    Reputation
    11,500
  • #3
    John Saffrahn
    Reputation
    11,440
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Chevrolet Silverado 1500
214 Great Deals out of 8,009 listings starting at $1,500
Used Ford F-150
314 Great Deals out of 13,742 listings starting at $3,800
Used GMC Sierra 2500HD
36 Great Deals out of 2,200 listings starting at $3,000
Used Toyota Tundra
33 Great Deals out of 984 listings starting at $10,698
Used Chevrolet Silverado 2500HD
33 Great Deals out of 1,683 listings starting at $3,000
Used Toyota Tacoma
44 Great Deals out of 742 listings starting at $9,975
Used GMC Yukon
14 Great Deals out of 981 listings starting at $3,000
Used Dodge RAM 1500
3 Great Deals out of 90 listings starting at $2,500
Used Chevrolet Tahoe
13 Great Deals out of 822 listings starting at $9,980
Used Ford F-250 Super Duty
24 Great Deals out of 786 listings starting at $4,290
Used GMC Canyon
23 Great Deals out of 896 listings starting at $5,477

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.