how replce fuel tank

Asked by Apr 05, 2017 at 12:29 AM about the 2007 Ford Five Hundred

Question type: General

fuel  tank how replace to

4 Answers


Should be about like any other, pull off gas cap. See where the filler neck needs to be loosened up may need to remove some bolts there at filler door. Look under the rear of the car and see where the filler tube is ans if there is any clamps or other items that need took off or undone in-order to remove the tank when ready, then look at tank see if it has a cover on it if so remove it and the then the tank straps are there but do not loosen them yet. "Rest is Quote from a Website" Remove the rear lower seat cushion. Release the latches and pull upward on the rear lower seat cushion and remove. Position the rear floor carpet and any padding or insulation covering the fuel pump module access cover aside. Remove the fuel pump module access cover. Clean the surrounding area of the fuel pump module mounting flange and the quick connect couplings with compressed air. Disconnect the fuel pump module electrical connector. Place absorbent pads in the general work area in case of fuel spillage. You may have to relieve the fuel pressure. Disconnect the rear fuel supply tube-to-fuel pump module quick connect coupling. Disconnect the fuel vapor control tube assembly valve-to-fuel pump module quick connect coupling. nstall the special tool and remove the fuel pump module lock ring. Carefully lift the fuel pump module out of the fuel tank allowing access to disconnect the crossover tube quick connect couplings. Disconnect the crossover tube-to-fuel pump module quick connect couplings. If leaving the pump in continue to loosen the tank straps and drop tank if removing the pump too Completely remove the fuel pump module from the fuel tank. To install new pump remove old O 'Ring and install new one and apply clean engine oil to the new O-ring seal. Reverse the removal procedure. Make sure the alignment arrows on the fuel pump module and the fuel tank meet before tightening the fuel pump module lock ring. Tighten the fuel pump lock ring until it meets the stop tabs on the fuel tank.


Take it to someone else to do, it is not fun, pain in the butt.

Why do the light comes onto check fuel cap?


Make sure it is on tight.

Your Answer:

Five Hundred

Looking for a Used Five Hundred in your area?

CarGurus has 13 nationwide Five Hundred listings starting at $3,800.

Postal Code:

Ford Five Hundred Experts

  • #1
  • #2
  • #3
View All

Related Models For Sale

Used Ford Taurus
6 Great Deals out of 345 listings starting at $5,795
Used Ford Fusion
41 Great Deals out of 1,940 listings starting at $1,500
Used Ford F-150
163 Great Deals out of 11,156 listings starting at $1,900
Used Ford Explorer
35 Great Deals out of 2,394 listings starting at $3,995
Used Ford Escape
173 Great Deals out of 6,506 listings starting at $993
Used Mercury Sable
1 listing
Used Chevrolet Impala
34 Great Deals out of 1,046 listings starting at $1,994
Used Toyota Camry
62 Great Deals out of 1,812 listings starting at $2,000
Used Ford Mustang
48 Great Deals out of 1,606 listings starting at $1,980
Used Nissan Altima
74 Great Deals out of 1,534 listings starting at $710
Used Chevrolet Silverado 1500
98 Great Deals out of 9,589 listings starting at $3,000
Used Ford Focus
80 Great Deals out of 2,570 listings starting at $2,000
Used Dodge Charger
53 Great Deals out of 943 listings starting at $4,750

Used Cars for Sale

2007 Ford Five Hundred For Sale
2 listings starting at $3,800

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.