I have a 2005 kia sorento and i installed a new fuel pump and im trying to put a aftermarket fuel gauge because my stock guge doesnt work, my aftermarket works but when the car mover the needle swing up and down. I would like to know wht to do make it steady when driving the car

Asked by Luis Jan 13, 2013 at 03:06 PM about the 2005 Kia Sorento EX

Question type: Maintenance & Repair

6 Answers

175,805

There's not much you can do without electronics training. The fuel gauge is actually a electrical volt meter like all electric gauges. Power is applied to one side and the sending unit in the tank provides a variable ground connection. A full tank raises the float and the most current is allowed to pass. A series/parallel circuit would have to be developed to attenuate the signal. The circuit that did that is built into your gauge cluster. You could try wiring your new gauge into the old gauge circuitry. Your other option is to live with it and check your fuel level when stopped or driving at a steady rate. If the needle stops dancing, there is not enough fuel to raise the float so find a gas station.

2 people found this helpful.

So if i decide to wire my new gauge to the old gauge circuit, how can i do that? My stock cluster the fuel needle is always in half tank even with the car off. Whn switch on then it moves all the way up and i only have 1/4 of gas in the tank. So can i wire my new gauge to the stock circuit but is it located in the cluster circuit or in the plugs in the fuel pump, there is two plugs, 1 that has 2 wires and the other has 4wires.

7,600

before you go to nuts with putting in a new fuel gauge id pull the pump back out to be sure you dont have the float caught on a baffle in the fule tank or the pump in a little off center and its holding up the float. in almost ten years of working on kias ive never seen a bad fuel guage , but yours could be the first ive heard of.

3 people found this helpful.
40

Mine is the same Sometimes it says it fill and other times to stays on E even when I have filled the tank WHAT A PAIN..... Does the entire gas tank need to be replaced as thats going to be quite costly

4 people found this helpful.
270

must be a common problem, mine when i fill my tank needle will register correctly for the first 40/50 miles. then drops to empty, i have to set the trip gauge and go by mileage. its a pain because i have to completely fill the tank each time i fill it..

2 people found this helpful.
10

I know this is an old thread but if anyone can please give me some advice on why or how to fix my fuel gauge on a 2006 Kia sorento, I would greatly appreciate it. It stays on Empty and needle never moves. Fuel light stays on all of the time and I have replaced the fuel pump assembly with sending unit, checked grounds and rechecked fuel pump assembly and float 3 times. What would be the easiest and best way to replace or repair gauge

1 people found this helpful.

Your Answer:

Sorento

Looking for a Used Sorento in your area?

CarGurus has 1,712 nationwide Sorento listings starting at $1,500.

Postal Code:

CarGurus Experts

  • #1
    5240
    Reputation
    2,460
  • #2
    Paul
    Reputation
    1,530
  • #3
    Edel Erum
    Reputation
    1,310
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Kia Sportage
58 Great Deals out of 1,933 listings starting at $3,999
Used Hyundai Santa Fe
44 Great Deals out of 1,706 listings starting at $499
Used Toyota Highlander
37 Great Deals out of 814 listings starting at $8,495
Used Ford Explorer
53 Great Deals out of 2,231 listings starting at $7,990
Used Honda CR-V
157 Great Deals out of 4,953 listings starting at $440
Used Honda Pilot
33 Great Deals out of 792 listings starting at $2,495
Used Toyota RAV4
111 Great Deals out of 2,857 listings starting at $2,949
Used Jeep Grand Cherokee
121 Great Deals out of 3,487 listings starting at $4,950
Used Hyundai Tucson
93 Great Deals out of 2,515 listings starting at $2,450
Used Nissan Pathfinder
40 Great Deals out of 1,713 listings starting at $190

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.