Forester using oil

10

Asked by Donn Dec 26, 2015 at 01:33 AM about the 2007 Subaru Forester 2.5XS

Question type: Maintenance & Repair

Forester 2.5 XS 2007, big end bearing kicked out due to lack of oil,
damaged crank etc... Engine largely overhauled, new pistons, rings, crank,
bearings.....Original question, why i had no oil as there was no leak and i
was not blowing smoke, and now after the overhaul, I have the same
problem. I am replacing oil at the rate of 1lt per 10 days! And before it
happened no oil light, engine light or warning, and the oil was EMPTY??

What could be the reason of excessive oil consumption, with leaks and
rough pistons and rings ruled out? I have stumped a Subaru specialist who
fixed the car....

15 Answers

http://www.consumeraffairs.com/news/subaru-owners-complain-of-engine-failure-high-oil-consumption-092315.html -- "While we believe the oil consumption of our vehicles to be within acceptable levels...." Out of context, granted but still shows their attitude.. Then: http://www.consumerreports.org/cro/magazine/2015/06/excessive-oil-consumption/index.htm --Subaru considers a quart burned every 1,000 to 1,200 miles to be acceptable. -- What I know for a fact is my Toyota consumes ½ quart in 3500 miles between changes

4 people found this helpful.
188,225

Another Fosrester with Oil issues...

3 people found this helpful.
157,115

This makes me wonder if the crank bearing initially went out due to low oil level and lack of lubrication. Then when it was overhauled were the piston rings installed in the correct orientation, were the cylinder walls honed to the proper cross hatch pattern or is something else causing the issue? A wonder if pistons and bearings were even properly measured when the engine was reassembled. Were the cylinder heads disassembled and checked, were valve guide seals replaced? There are lots of places oil can go if engine is not built properly. Having a manufacturer specialist do the work is usually a good thing. The more problems I read about Subaru the less I like their cars. Please keep us posted as to what you find the resolution to this problem is as it may help someone else. Best of luck with it.

2 people found this helpful.

What I don't seem to be able to grasp Bob is if there is no smoke, no leaks, no puddles on driveway, some oil consumption I can understand that will show none these symptoms. But a quart in 1000 miles? Where is it going? If, as you say, and I agree, if the rings were not oriented correctly, 'staggered' where gaps are, honed properly and not grind grind grind with whetstone rotary honer then not put proper rings or even pistons, seems to me it would blow smoke...? I just don't get where all this oil is going

1 people found this helpful.
157,115

The catalytic converter will burn lots of the oil up and that probably accounts for minimal or no smoke. A quart in 1000 miles is not much oil per mile. I wonder if some of the #1 and #2 rings were installed upside down or if the cylinder is out of round or has excessive taper.

2 people found this helpful.
157,115

To increase the viscosity at operating temperature the number after the "w" need to increase. A 5w30 and 10w30 are the same viscosity at operating temperature. A great read on oil is here at the link......http://www.bobistheoilguy.com/motor-oil-101/

2 people found this helpful.

The 07 Subaru's do not use the 0-20 oil so oil consumption should not be an issue at all. I suspect the rebuild was not the best and maybe the cylinders were not honed properly or were worn and should have been bored out and over sized pistons installed. A quart in a thousand miles won't necessarily show any smoke burning especially with a catalytic converter.

3 people found this helpful.
10

Thanks to all your info and input. I should've started off by saying this issue was there before the engine was done. Virtually replacing the capacity of the oil tank of 4.5lt every 2 months just doesn't seem right to me....(we here on the metric system, so not sure how many quarts that is. It consumes about 2lt of oil in 2000km).

1 people found this helpful.
47,960

Does sound like your rings are a mess. Maybe piston slap scored a cylinder too. Your consumption is/was too high...unless 0w.

10

Had this problem with our 2014 forester. Was due to incorrect oil viscosity. Used the genuine subaru 0w- 20 engine oil and it hasn't burnt a drop! Not sure what oil was in it previously, also had non genuine oil filter from purchase 2nd hand. I'm a fully qualified mechanic and have never seen such consumption of oil in a new vehicle like ours had at at first.

1 people found this helpful.

I have the same exact problem with my 2006 Impreza 2.5. My bearing went as well. Only, I’m burning appropriately 1L per 500km. It’s way too much and very frustrating. No leaks. No smoke either.

10

We're in the same boat. 2007 Forester that I wound up replacing the cylinder head gaskets, and 1 of the cylinder heads due to 4 hair line cracks when the last owner's daughter over heated the snotballs out of the engine. (It dropped 3 of the 4 exhaust valve guides to the point one of them was snapped.) Engine runs like a top! Zero oil burning that we can see. Very minor drip from the oil pan drain plug (still pi&&ed about that. I went with a new plug and gasket and even torqued it to specs).. That minor drip might account for a tablespoon ever few days loss- But we are using about a quart a week. (350-400 miles average). Zero leakage other then the drain plug gasket. We're just monitoring it and topping it off as needed. I used 5w30 syn with a quality filter. It might be harder on the engine, but I am considering changing it to dyno oil at 10w40 to staunch the usage. (And dyno oil would be a lot cheaper then $6+ a quart for syn oil it's going through)

47,960

5w30 is a bit skinny for that motor. I'd go with 10w40 dino and change 4x/yr or synth and change semi-annually. Nonetheless, your consumption is higher than expected. Try a new drain plug gasket next change.

1 people found this helpful.

Your Answer:

Forester

Looking for a Used Forester in your area?

CarGurus has 1,365 nationwide Forester listings starting at $3,995.

Postal Code:

CarGurus Experts

  • #1
    Chris W
    Reputation
    11,360
  • #2
    TheSubaruGuruBoston
    Reputation
    9,750
  • #3
    Nick Eidemiller
    Reputation
    6,210
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Subaru Outback
52 Great Deals out of 1,084 listings starting at $3,495
Used Toyota RAV4
124 Great Deals out of 2,931 listings starting at $6,950
Used Honda CR-V
156 Great Deals out of 4,959 listings starting at $440
Used Toyota 4Runner
18 Great Deals out of 514 listings starting at $6,825
Used Subaru Impreza
36 Great Deals out of 652 listings starting at $5,995
Used Subaru Legacy
27 Great Deals out of 210 listings starting at $3,495
Used Toyota Highlander
44 Great Deals out of 818 listings starting at $8,495
Used Toyota Tacoma
43 Great Deals out of 682 listings starting at $9,975
Used Toyota Camry
45 Great Deals out of 1,150 listings starting at $3,900
Used Honda Pilot
29 Great Deals out of 790 listings starting at $2,495
Used Nissan Rogue
122 Great Deals out of 4,988 listings starting at $3,495

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.