why won't my check engine turn off?

Asked by Baird Jun 28, 2020 at 08:26 PM about the 2003 Ford Escape XLT FWD

Question type: Maintenance & Repair

My 2003 Escape XLT has a trouble code of P0403, the EGR system. I have
changed out with new parts, the entire system, all 3 components. Ive
cleaned the tube to the plenum I've even changed the plenum gaskets and I
can't get the Check Engine Light to turn off so I can smog it. I've reset the
computer , nothing works. WTF is going on. Does the Catalytic converters
have their own code if they were the issue? Please help.

1 Answer
155,145

james answered 3 years ago

P0403 is telling us there's a problem with the EGR vacuum control solenoid or the wiring going to the solenoid. There's a short or open condition in the circuit. Carefully inspect the wiring going to the solenoid and the electrical connection at the solenoid. Look for breaks, damage, or corrosion that will cause a bad connection. If all this checks out good, replace the solenoid. Once you clear the computer, after the repair, drive a few days with the gas gauge between three quarters and one quarter full so the computer will run the diagnostics on the EGR system and set the readiness monitors for smog inspection. Hope that helps! Jim

Mark helpful

Your Answer:

Related Questions

  • why won't my check engine turn off? 1 Answer

    My 2003 Escape XLT has a trouble code of P0403, the EGR system. I have changed out with new parts, the entire system, all 3 components. Ive cleaned the tube to the plenum I've even changed the plenu...

    2003 Ford Escape XLT FWD

    -

    Maintenance & Repair

  • Why won't my car start. 1 Answer

    I recently installed a used transmission in my car. It started and ran good for a day or two. Now it's just went start or even turn over. I checked the starter. I just dont know what else to do.

    2001 Ford Escape XLT FWD

    -

    Maintenance & Repair

  • Check engine light wont stay off 3 Answers

    I have a 2003 Ford Escape 6 cyl. I've replaced all 3 components in the EGR system. the EGR valve, the pressure feedback sensor and the control switch. I cant get the dang light to stay off and there...

    2003 Ford Escape Limited AWD

    -

    Maintenance & Repair

  • why wont my car turn over? 1 Answer

    so i was sitting in my car and all off a sudden the radio turned off but everything else was fine so i turned off my car and tried to turn it on again and the car wouldnt turn over, figured its the ...

    2002 Ford Escape XLT FWD

    -

    Maintenance & Repair

  • Why did the engine turned off when it had turn on 1 Answer

    Checked the batterie and its in good condition. When trying to turn on again the inside lights wiil not turn on at all

    Ford Escape

    -

    Maintenance & Repair

Shortcuts

Search Ford Escape Questions

CarGurus Experts

  • #1
    Bratts
    Reputation
    4,460
  • #2
    Gene Arnett
    Reputation
    3,990
  • #3
    KenF
    Reputation
    3,600
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Ford Explorer
71 Great Deals out of 2,016 listings starting at $3,333
Used Toyota RAV4
122 Great Deals out of 3,074 listings starting at $3,900
Used Honda CR-V
182 Great Deals out of 5,035 listings starting at $440
Used Ford F-150
336 Great Deals out of 13,399 listings starting at $3,000
Used Toyota Camry
52 Great Deals out of 1,161 listings starting at $4,594
Used Ford Focus
19 Great Deals out of 525 listings starting at $2,995
Used Honda Civic
175 Great Deals out of 4,082 listings starting at $440

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.