2004 Ford Escape driveline vibration

Asked by jminatta Nov 27, 2010 at 05:24 AM about the 2004 Ford Escape XLT AWD

Question type: Maintenance & Repair

My '04 Escape has around 87,000 miles on it.  About 1000 miles ago, it started having a very slight vibration in the 8 to 20 mph range.  It has consistently been getting worse.  I now feel the small vibration at 55 mph.  I haven't driven it in 4 1/2 months because of it.  I bought a used drive shaft from a junk yard for $60.00.  Haven't done anything with it since.  What tools do I need and are there any special precautions I need to take when doing this job?  I don't have a whole lot of cash to burn on it but will buy the right parts needed to fix it.  Any feedback will be greatly appreciated.  Complete job instructions would be better.  I have a degree in diesel mechanics so I am inclined to understand, I just need to know what I'm up against.

3 Answers

papa answered 13 years ago

first put in new u joints,which you could have done to yours,is a easy swap at rearend unbolt the u clamps on u joint,10 mm wrinch their are 2 of them remove pull driveshaft out replace you will have to turn it some for the splines to line up push in ,put u clamps back.other causes out of balance tires bad tie rod,Idle arm worn shocks struts.when you take out driveshaft, put tranny in nutural,jack up rearend use safty stans,as you will have to turn driveshaft to get to bolts and put it back in,block front wheels to keep from roling.

1 people found this helpful.
Mark helpful

jminatta answered 13 years ago

I forgot to mention that the emergency brake cable plastic holder broke, causing the e-brake cable to fall down and ride on the rear drive shaft cutting a nice groove into the shaft. This may in some way be the problem but either way the rear shaft has to go. From what I understand, these are a balanced unit. Replace one part and it had to be balanced with the other prior to installation.

Mark helpful

papa answered 13 years ago

NO it dont need to be rebalanced all are factory balanced the same.

2 people found this helpful.
Mark helpful

Your Answer:

Related Questions

  • 2004 Ford Escape driveline vibration 3 Answers

    My '04 Escape has around 87,000 miles on it. About 1000 miles ago, it started having a very slight vibration in the 8 to 20 mph range. It has consistently been getting worse. I now feel the small v...

    2004 Ford Escape XLT AWD

    -

    Maintenance & Repair

  • 2004 Ford Escape 3.0 Engine Vibration 4 Answers

    While I was driving today out of no where my check engine light started to blink and the car developed a vibration similar to when you have a lose tire. It had snowed 3 inches over night here and ...

    2004 Ford Escape Limited AWD

    -

    Maintenance & Repair

  • Ford Escape 2004 4x4 45mph+ vibration 20 Answers

    Approx 100,000 miles on Escape - Vibration detectable at about 45 mph and gets significantly worst toward 65 mph. Not consistent however- Sometimes does not occur during below freezing Temp for und...

    2004 Ford Escape Limited AWD

    -

    Maintenance & Repair

  • 2004 ford escape 4 Answers

    My 2004 ford escape will only crank if i turn the key on and off about 10 times. You can hear the fuel pump turn on for 2 seconds each time you turn it on. Any thoughts as to what is wrong?

    2004 Ford Escape

    -

    Maintenance & Repair

  • 2004 Ford escape over drive 1 Answer

    My 2004 Ford escape XLT will not go into overdrive. Automatically nor manually. It has the push button on the shifter, which is up on the column but it does nothing. Is there a fuse or a relay or ...

    2004 Ford Escape XLT FWD

    -

    Maintenance & Repair

Escape

Looking for a Used Escape in your area?

CarGurus has 4,216 nationwide Escape listings starting at $3,495.

Postal Code:

Shortcuts

Search Ford Escape Questions

CarGurus Experts

  • #1
    Bratts
    Reputation
    4,460
  • #2
    Gene Arnett
    Reputation
    3,990
  • #3
    KenF
    Reputation
    3,600
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Ford Explorer
61 Great Deals out of 2,048 listings starting at $6,990
Used Honda CR-V
181 Great Deals out of 5,013 listings starting at $440
Used Toyota RAV4
127 Great Deals out of 3,065 listings starting at $4,999
Used Chevrolet Equinox
102 Great Deals out of 3,331 listings starting at $1,695
Used Ford F-150
325 Great Deals out of 13,693 listings starting at $3,800
Used Ford Escape Hybrid
14 Great Deals out of 680 listings starting at $7,990
Used Ford Focus
16 Great Deals out of 506 listings starting at $2,995
Used Hyundai Tucson
105 Great Deals out of 2,758 listings starting at $3,999
Used Toyota Camry
44 Great Deals out of 1,134 listings starting at $4,795
Used Honda Civic
192 Great Deals out of 4,047 listings starting at $440
Used Subaru Forester
39 Great Deals out of 1,353 listings starting at $3,995

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.