Why is my or cruiser overheating

Asked by Jocelyn Jul 24, 2018 at 02:16 PM about the 2009 Chrysler PT Cruiser Touring Wagon FWD

Question type: Maintenance & Repair

I have changed timing belt and water pump new
fuel pump and new thermostat with new hoses and
new cap for thermostat my car has over heated
before before changing water pump and timing belt
why is my car still over heating

2 Answers

100

Seems to be a common problem with the PT Cruisers. My daughter has one. It never overheated until I had timing belt/water pump changed. Then all of a sudden it will start slowly climbing toward hot after 30 minutes to an hour of driving. I've done a lot of research trying to figure this out (mainly because my daughter can't wait 4 or 5 days without a vehicle so Dodge/Chrysler can look at it). Everything seems to point towards a leaking head gasket, but I did a block (chemical-vapor) test and there is no leaking head gasket. I've done everything (replaced engine coolant temperature sensor, radiator cap, thermostat, coolant flush with new Chrysler HOAT coolant, pressure test on coolant system, etc) and I can't find the problem. I've read that many solved their problem with a new radiator. You can get one at AutoZone for $150 if you know how to swap them out. I don't think that's my problem because my old coolant wasn't that dirty, and I peeked inside the bottom of the radiator and it was fairly clean. Could be your problem, I don't know. Depends on if you want to roll the dice and try it. I reckon it would cost $400 or so to have a respectable mechanic do the radiator swap (radiator plus labor). As for me, I think I'm done with Daimler/Dodge/Chrysler products, and I've reached a limit on how much money I'm going to keep putting into this vehicle. It's about to get traded in for a new Honda Civic, and my daughter will get my wife's used SUV. This PT Cruiser has consumed enough of my time and money. Time for it to go. Best of luck to you on yours ...

I have the same problem out of my pt crusier. Replaced all that including the radiator and it still overheats and the family won't run on its own but it will run if you connect it to the battery. Wiring harness but you can't buy them at parts stores and I have being to 5 junkyards no luck they cut the wiring

Your Answer:

CarGurus Experts

  • #1
    Kelly Little Ashford
    Reputation
    4,400
  • #2
    Gypsy Rose
    Reputation
    3,280
  • #3
    docwade931
    Reputation
    2,750
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Chevrolet HHR
13 listings starting at $3,999
Used Chrysler Crossfire
14 listings starting at $6,990
Used Kia Soul
79 Great Deals out of 1,062 listings starting at $2,877
Used Volkswagen Beetle
12 Great Deals out of 182 listings starting at $2,495
Used Chrysler Sebring
25 listings starting at $3,995
Used Toyota Camry
45 Great Deals out of 1,150 listings starting at $3,900
Used Toyota Corolla
139 Great Deals out of 2,287 listings starting at $3,495
Used Chrysler 300
29 Great Deals out of 544 listings starting at $4,790
Used Ford Mustang
54 Great Deals out of 1,606 listings starting at $6,200
Used Ford Ranger
19 Great Deals out of 533 listings starting at $6,500
Used Dodge Caliber
26 listings starting at $3,750
Used Chevrolet Corvette
21 Great Deals out of 605 listings starting at $10,989
Used Honda Fit
14 Great Deals out of 183 listings starting at $5,500

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.