1992 Volvo 740 non-turbo regina ignition Wagon

25

Asked by FOMyers Aug 15, 2012 at 02:13 PM about the 1992 Volvo 740 Wagon

Question type: Maintenance & Repair

Hi,

My Volvo Station Wagon died suddenly while driving (near the end of a trip. Once towed home, I tested spark at coil and at plugs (good). I replaced fuel filter (we've had a rash of bad - watered - fuel from local stations lately). Cranked on the starter to see if that would fix it. It still will not fire.

So I opened the engine side fuel filter fitting. I have good preassure past the fuel filter. I have spark at the plugs. But it will not fire at all.

Any suggestions?

Frank

13 Answers

9,395

Have you tried starting it with starting fluid or other spray?

1 people found this helpful.
9,395

Does the engine sound normal? (Timing belt didnt skip or break did it?)

1 people found this helpful.
9,395

Do you have power at the fuel injectors? Can you smell fuel?

1 people found this helpful.
9,395

Sorry for the separate posts, I didnt want to condense my answers into a tight paragraph.... If the injectors arent getting power, fuses and relays check okay, and you dont smell fuel your PCM may be bad. Typically I only see the Bosch Pink Label units go bad... but then again I havent encountered many Regina's.

2 people found this helpful.
25

Thank you. I will try that. I also replaced the fuel pressure regulator. I suspect that the fuel injectors are not delivering fuel. Is there any way to test this?

25

The timing belt is intact. What triggers the fuel injectors? I see vacum lines running up to them, and they are obviously connected to the fuel injector rail, but no other obvious trigger mechanism... I don't see wires to trigger a selenoid, so I'm guessing it's not electronic fuel injection. The fuel is supposed to be at 300kpa at the rail, but there's no test port to hook up a pressure gague.

175

it sounds like you have water in your fuel see if you can undo a fuel pipe in front of the fuel pump get a can of fresh fuel put a pipe on and into the can and try to re start if this works drain fuel tank and re fuel you may need a two way connector to do this.

225

My '89 has the Bosch fuel injection so I'm not much help here...

1 people found this helpful.
9,395

The injectors are electronic....... Unplug one of the injector wires and probe it with a volt meter (an old analog meter is usually best, or a digital meter with a "max hold" setting... which will tell you what the max voltage seen was. Turn the car over and see if you get 12 volts. The power will be intermittent as the injector only gets power when it is time for that injector to squirt fuel.

9,395

I came across this as well. http://www.brickboard.com/RWD/volvo/1299222/940/960/980/V 90/S90/93_940_sedan_nostart_rexregina_vehicle.html

1 people found this helpful.
25

Ok. I found the problem. The timing belt is stripped. Injectors were fine, as were the plugs, etc.

175

http://www.bodyshopwarehouse.co.uk/category/740-23-23i- sedan-stationwagon-87-90 try this site it covers all

9,395

Ah! Belt looked good but the teeth were missing? Glad you figured it out!

2 people found this helpful.

Your Answer:

740

Looking for a Used 740 in your area?

CarGurus has thousands of nationwide listings and the tools to find you a great deal.

Postal Code:

CarGurus Experts

  • #1
    Christopher Paden
    Reputation
    340
  • #2
    tenspeed
    Reputation
    90
  • #2
    Peter Wright
    Reputation
    90
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.