No fuel pressure

15

Asked by xshuey May 08, 2012 at 11:05 AM about the 1991 Volkswagen Jetta GLI 16V FWD

Question type: Maintenance & Repair

I have a 1991 VW Jetta 2.0 16v . I just bought it from a friend . It has been sitting for a while. After charging the battery when I turn the key on I can hear the fuel pump in the gas tank run for a few seconds. but it won,t start .The gas is good. I have no fuel pressure at the  fuel filter back by the tank. Or up at the front of the car anywhere. Anybody have any ideas what might be wrong? have a Bently manual coming.

7 Answers

235

Is all the electrics good? The pump will make noise for few secs and then it will go slightly quieter, it could be a bad connection on it too, but I would check spark plugs&cablez, coil etc. maybe bad immobilizer?

2 people found this helpful.
Best Answer Mark helpful
15

Thanks, but I can get it to run if I give it a small shot of ether ,I know not too much cause you can blow a head gasket. It just isn't getting fuel. What is this immobilizer? And where is it?

1 people found this helpful.
595

I don't think jetta's had immobilisers in 1991

1 people found this helpful.
235

the pump itself is in the boot, under the black round cover, if it makes noise after u turn ignition on it should be fine, check the connections on it. If u can smell gasoline out of the exhaust when u trying to start her up its 100% electric if not than check the pump, fuel lines, throttle body (the tend to get stuck sometimes), could be a clog somwhere (maybe fuel filter needs changing). Don't use ether or u might mess it up even worse. I would maybe tow it and try start it with 2nd gear if this doesn't get her moving than could be that the pump died but since u said it does make some noise... Immobilizer is a device that cuts off electrics from the car and you would have no spark, not quite sure where it was hidden. Hope this helps, mine does that too from time to time but it starts in the end but no apparent reason for it

1 people found this helpful.
130

^^ These cars have two pumps and while the auxiliary in the tank may be running, the main fuel pump located under the vehicle is most likely not, this not allowing pressurized fuel to flow all the way up to the rail. Put rear of car on jack stands and engage pumps via jumper on fuse block 30 location and Z1 I believe. When you hear pump running get under vehicle and feel main pump underneath to see if it is running. If not, unplug it and apply multimeter across plug connections from harness and if you show 12-12.5v you have a bad main fuel pump. Wala. Doing simple electric system diagnostics will 99% of the time save you valuable time and keep you from throwing $$ at the problem. I know this is 2 years late but it might help someone else looking for some answers.

11 people found this helpful.

Your Answer:

Jetta GLI

Looking for a Used Jetta GLI in your area?

CarGurus has 217 nationwide Jetta GLI listings starting at $8,990.

Postal Code:

CarGurus Experts

  • #1
    Greg0Linda2
    Reputation
    110
  • #1
    Mark Schmidt
    Reputation
    110
  • #3
    Rowefast
    Reputation
    90
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Volkswagen Golf GTI
23 Great Deals out of 593 listings starting at $6,898
Used Volkswagen Jetta
76 Great Deals out of 1,946 listings starting at $2,495
Used Honda Civic
190 Great Deals out of 4,208 listings starting at $2,916
Used Toyota Camry
44 Great Deals out of 1,140 listings starting at $3,900
Used Volkswagen Passat
17 Great Deals out of 502 listings starting at $3,500
Used Honda Accord
59 Great Deals out of 1,026 listings starting at $2,995
Used BMW 3 Series
66 Great Deals out of 1,237 listings starting at $3,995
Used Ford F-150
363 Great Deals out of 12,802 listings starting at $599

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.