F250 Fuel gauge

Asked by Rfields947 May 01, 2013 at 02:20 PM about the 1997 Ford F-250 2 Dr XL 4WD Extended Cab LB HD

Question type: Maintenance & Repair

I have a 1997 Ford F250 Heavy Duty with a 7.3L,  it has dual gas tanks.  When i flip the switch to tank one, the gauge drops to empty.  There is diesel in the tank and it continues to run fine.  Any ideas on what is causing the gauge to drop to empty?

9 Answers

39,495

the sending unit is bad in one tank. either that or wires to it.

4 people found this helpful.
141,585

It could also be an open connection at the switch. The sending unit provides the ground for the gauge. The better the ground, the fuller the gauge. A empty gauge indication would be no needle movement due to no ground.

2 people found this helpful.
208,905

Agree it sounds like the sender, it is possible that the float has came off the sender and sits on the bottom so you get an empty reading. I believe that this year of Ford if you have an open circuit in the fuel gauge system the gauge goes past the full mark.

3 people found this helpful.
39,495

your right tennisshoes. Its susposed to read 145ohms when full and 22.5ohms when empty. An open condition would make it read over full. the signal is shorted to ground somewhere. you could unplug the sender on the affected tank and if it reads full then you know its the sender. if it doesnt change you have a wire shorted to ground.

7 people found this helpful.
1,420

the switching valve under the truck also switches the gauge circuit. lots of salt and water down there check for corrosion in the elec. connections. it may require a new valve

2 people found this helpful.
255

I just replaced my rear tank and fuel pump on my 89 F250 with 351W. when the tank is full it reads normal till 3/8 of tank left and the gauge will start to rise back up to full.

3 people found this helpful.
20

Christopher On my 1997 7.3 rear tank was reading empty when it was full. Ford wanted $500.00 for new fuel sensor. I took my tank down and removed the sending unit and found my float was full of fuel and had a crack in it. I found a new float on Amazon made of brass like the original and the cost was like $12.00 it just snapped in to the arm

2 people found this helpful.

The wire harness only has 2 wires going to the tank and the tank harness has 4 wires coming out

208,905

GuruH413R late model fuel tanks have 4 wire connectors, power and ground for the fuel pump and the fuel gauge signals in and out wires. in other words wrong tank for your rig.

Your Answer:

F-250

Looking for a Used F-250 in your area?

CarGurus has 3 nationwide F-250 listings and the tools to find you a great deal.

Postal Code:

Ford F-250 Experts

  • #1
    G A Arne
    Reputation
    1,430
  • #2
    F_O_R
    Reputation
    780
  • #3
    MikeSt
    Reputation
    710
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Ford F-150
197 Great Deals out of 12,239 listings starting at $521
Used Dodge RAM 2500
65 listings starting at $7,595
Used Ford F-350
2 listings
Used GMC Sierra 1500
112 Great Deals out of 10,157 listings starting at $2,500
Used Dodge RAM 1500
10 Great Deals out of 297 listings starting at $3,900
Used Ford Mustang
26 Great Deals out of 1,836 listings starting at $1,048
Used Toyota Tacoma
36 Great Deals out of 2,008 listings starting at $6,995

Used Cars for Sale

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.