How to repair a 2003 Chevy Impala cooling system.

40

Asked by tismeinaz Nov 20, 2014 at 07:58 PM about the 2003 Chevrolet Impala LS FWD

Question type: Maintenance & Repair

We have put in a new radiator, new water pump and a new thermostat but the car still runs hot.  It is a 2003 Chevy Impala.  Please help if you have a suggestion.  Thx.

18 Answers

62,675

Have you checked the temperature sending unit for accurate readings?

2 people found this helpful.
143,545

I agree with Bmark,the only other thing that may be doing this if the guage is right,would be internal intake gasket or head gasket.

3 people found this helpful.
40

He (Sorry, I used the editorial we in the question as I am just doing the typing-husband is on the phone and I am relaying his question) said that he didn't test it but that he feels sure it is not accurate as it can read 260 and the engine doesn't feel hot yet at other times the engine is extremely hot and the hot signal does not even come on. At times the hot signal comes on yet drive another few blocks and it goes back down to normal. I do know for a fact that I have to put water in the radiator every time I drive the car. I can run to the store less than a mile away and by the time I get back the water is gone. We can't figure out where the water is going. It was leaking from the gasket on the thermostat but that was replaced yesterday and the water is still gone.

40

No leaks that we can see both with the engine running and/or shut off. No water in the oil nor coming out of the tail pipe. No oil in the water - just can't figure this out.

1 people found this helpful.
143,545

If you are loosing water this fast,i think you may have and internal leak,meaning intake gasket,it may be burning it off through the tail pipe,rev car up,with white rag on tail pipe a few time,s,rag will get damp,if it is this,

1 people found this helpful.
40

So if the gauge is not accurate and the engine is definitely hot than it would be one of those two gaskets?

40

Is that easier to repair than the head gasket? I sure hope so as my husband and my neighbor are both "shade tree" and I am beginning to wonder if my car will ever be okay. I will try the rag test myself. Be back in just a few minutes. Thank you so much for answering me.

1 people found this helpful.
40

Yes, I just did the white rag test and the rag is wet. I didn't have it tight enough on the tail pipe the first time and when I rev'd up the car it came off. The driveway right behind the car was wet. I put the rag back tighter and rev'd up the car again and the rag did get wet. Not sopping wet but wet not the less. Also when I raced the motor with my foot on the gas pedal the engine was slowing down and speeding back up as if I was taking my foot off and on - but I wasn't. It was doing it on its own. I held my foot steady but the motor kept backing off and then speeding up again.

1 people found this helpful.
143,545

This is a definate sign of gasket blown,tell your hubby to go rent a compression tool,from autozone,or advance,it want cost him,he will get his money back when he take,s it back,then pull one plug at a time,screw the guage in to plug hole,and turn car over do this on each plug,when he get,s to the one that don,t holed the pressure that will be the blowed one,this is only to confirm the intake gasket is blowed,and the car run,s bad because the water is mixing in the cylinder and having to try to burn water.

1 people found this helpful.
Best Answer Mark helpful
40

Of my goodness - thank you so much. We have asked everyone around here and no one knew. You are very smart. If he get someone to replace that gasket then will my care be okay?

143,545

Im pretty sure that it is the intake,have you pulled the oil stick?And checked it for water?

143,545

Good,that is a definate ,,no head gasket problem,it will be the intake gasket,and yes it will fix your car >>>>: )

1 people found this helpful.
143,545

Bless you back,and good luck with it.

2 people found this helpful.
10

The original chevy impala ran hot while idling at lights. I had to put a transmission cooler on mine to stop it. The cost is about $250 but well worth it.

1 people found this helpful.
10

I have a 2003 Impala 3.4 Base. I had the same problems. The 2003 was notorious for lower intake gaskets and head gasket problems. I had to replace both. Took care of the problems.

1 people found this helpful.

Your Answer:

Impala

Looking for a Used Impala in your area?

CarGurus has 136 nationwide Impala listings starting at $3,990.

Postal Code:

CarGurus Experts

  • #1
    Rowefast
    Reputation
    6,110
  • #2
    james sparrow
    Reputation
    4,630
  • #3
    dandyoun
    Reputation
    4,070
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Chevrolet Malibu
46 Great Deals out of 1,132 listings starting at $2,995
Used Honda Accord
59 Great Deals out of 1,026 listings starting at $2,995
Used Chevrolet Camaro
25 Great Deals out of 511 listings starting at $11,500
Used Toyota Camry
44 Great Deals out of 1,140 listings starting at $3,900
Used Chevrolet Silverado 1500
222 Great Deals out of 9,112 listings starting at $2,900
Used Chevrolet Tahoe
18 Great Deals out of 859 listings starting at $9,980
Used Jeep Grand Cherokee
121 Great Deals out of 3,487 listings starting at $4,950
Used Nissan Maxima
15 Great Deals out of 208 listings starting at $3,995
Used Ford Mustang
61 Great Deals out of 1,603 listings starting at $6,500

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.