have new flex plate new starter new crankshaft pos. sensor still braking of teeth from flex plate

Asked by myk Aug 15, 2007 at 07:34 AM about the 1997 GMC Savana Cargo G2500 Cargo Van

Question type: Maintenance & Repair

Befor I got the van a new starter was put in and a new flex plate, it started 6 or 7 times was put out side wating on other parts, 3 days later whent out to start it and it broke of teeth from the flex plate, new flex plate put in and a crankshaft sensor, still doing the same thing, is there a diffrent starter for the van it has the 5.7 lt eng. and the 4L80E trans?

83,745

littlehorn answered 16 years ago

Is the starter shimmed properly? When reinstalling replacement GM starters, it is essential to find the proper amount of shimming required to space the starter so that it engages the teeth of the flywheel properly. There is a procedure for doing this which is described in the packet that should come with your starter. Typically between 0.020-0.035" of shimming is required to prevent problems with the starter bendix over or under-engaging the teeth.

1 people found this helpful.

Mark helpful

myk answered 16 years ago

No shimes, the problem is that it is to faraway and not ingaging enougth of the teeth, the saluation that I have come up with was that I ground down the mounting serface, now it has full contact with the teeth and it not braking them off any more

1 people found this helpful.

Mark helpful

GuruFDWLR answered 4 years ago

But, now, the torque converter is further away from the transmission... You'll end up braking the gear it pushes into.

Mark helpful

Your Answer:

have new flex plate new starter new crankshaft pos. sensor still braking of teeth from flex plate 3 Answers

Befor I got the van a new starter was put in and a new flex plate, it started 6 or 7 times was put out side wating on other parts, 3 days later whent out to start it and it broke of teeth from the fle...

1997 GMC Savana Cargo G2500 Cargo Van

-

Maintenance & Repair
My flex plate is in backwards, is that possible? 1 Answer

I had the flex plate replaced and the starter works for a while and then starts grinding, had the starter replaced thinking that was bad and the guy told me the flexplate is in backwards

1999 GMC Savana Cargo G3500 Cargo Van Extended

-

Maintenance & Repair
i have a 2001 gmc savana 3/4 ton 5.7 vortec, i am having problems with a rough/low idle and it dies under load and has no power. i have replaced the fuel pump, fuel filter, spark plugs wires, plugs, rotor, cap, air filter, MAF sensor, TPS sensor, idle air control sensor, EGR valve. i am out ideas please help. By the way i have NO codes. 1 Answer

i have a 2001 gmc savana 3/4 ton 5.7 vortec, i am having problems with a rough/low idle and it dies under load and has no power. i have replaced the fuel pump, fuel filter, spark plugs wires, plugs,...

2001 GMC Savana Cargo G3500 Cargo Van Extended

-

Maintenance & Repair
periodic hard shifting 3 Answers

I had to replace intake manifold gaskets, did not realize, I broke coolant sensor, on test drive experienced hard shifting. By chance I thought may the coolant sensor had something to do with the pro...

1997 GMC Savana Cargo G2500 Cargo Van

-

Maintenance & Repair
Won't start or stay on 3 Answers

Driving stopped at light it goes dead no warning acts like the battery is dead. .try jumping it still acts like the battery's dead i have a new alternator. And i tested the battery said it's full ...

1997 GMC Savana Cargo G2500 Cargo Van

-

Maintenance & Repair

Looking for a Used Savana Cargo in your area?

CarGurus has 371 nationwide Savana Cargo listings starting at $7,995.

Used GMC Savana

28 listings starting at $14,900

Used Ford Transit Cargo

42 Great Deals out of 1,055 listings starting at $11,975

Used Ford E-Series

6 Great Deals out of 168 listings starting at $6,900

Used Chevrolet Express

53 listings starting at $14,490

Used GMC Sierra 1500

139 Great Deals out of 8,257 listings starting at $3,000

Used Ford F-150

325 Great Deals out of 13,693 listings starting at $3,800

Used Mercedes-Benz Sprinter

3 Great Deals out of 44 listings starting at $18,500

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.

have new flex plate new starter new crankshaft pos. sensor still braking of teeth from flex plate

3 Answers

Your Answer:

Looking for a Used Savana Cargo in your area?

Shortcuts

Search GMC Savana Cargo Questions

CarGurus Experts

Find great deals from top-rated dealers

Related Models For Sale

have new flex plate new starter new crankshaft pos. sensor still braking of teeth from flex plate

3 Answers

Your Answer:

Related Questions