Starter noise

Asked by Zman2u Jul 23, 2016 at 04:40 AM about the 1994 Ford Explorer 4 Dr XLT SUV

Question type: Maintenance & Repair

I just replaced the starter in my 94' Ford Explorer, it started like a charm
several times. I drove it a while and had no problems until the final time I
went to start it and it made a terrible noise. Car started but sounded as
though the bendix was still turning in the starter and hitting the fly wheel. I
was able to drive fine but the noise never stopped? Even after I arrived to
my home and turned it to off the noise never stopped? It sounded as loud
as I have ever heard a noise from under the vehicle? After turning the
ignition to on and off again it died out with what appeared to be due to low
battery amps, everything dimmed and shut off temporarily and then flicked
back on once the noise subsided? If you can understand this please help!

5 Answers

64,350

Check to make sure the starter bolts have not come loose. Retighten if the have.

1 people found this helpful.
157,115

Check the starter solenoid to see if it is stuck. That will cause the starter to run all the time, even with the key off.

1 people found this helpful.

I will check all those things and hope it's not the tranny, But Bob how do you check the Starter solenoid to see if it is stuck, how can I tell if it's stuck? All the power returned to the car once I turned it off Tennisshoes? I hope its just loose bolts Firebird338!

157,115

You can test it by taking loose the wires and checking for continuity between the large posts using an ohm meter. It should have infinite resistance and not show a reading when measured between the large posts. If the starter shuts off when the ignition switch is off then the solenoid is not stuck. Aftermarket solenoids are known for this and genuine Ford is best when a replacement is needed.

1 people found this helpful.

Thanks Bob for your quick response. I'm under the car now and checking the starter for damage, because driving it home like that could have damaged the bendix or the flywheel im sure? I certainly hope not but I don't want to try and start it until I check those things. Thanks again.

Your Answer:

Explorer

Looking for a Used Explorer in your area?

CarGurus has 2,231 nationwide Explorer listings starting at $7,990.

Postal Code:

CarGurus Experts

  • #1
    OJ
    Reputation
    30,840
  • #2
    TransAm77
    Reputation
    7,790
  • #3
    Gene Arnett
    Reputation
    7,280
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Ford F-150
363 Great Deals out of 12,802 listings starting at $599
Used Chevrolet Tahoe
18 Great Deals out of 859 listings starting at $9,980
Used Jeep Grand Cherokee
121 Great Deals out of 3,487 listings starting at $4,950
Used Toyota 4Runner
20 Great Deals out of 517 listings starting at $6,825
Used GMC Yukon
17 Great Deals out of 941 listings starting at $5,998
Used Nissan Pathfinder
40 Great Deals out of 1,713 listings starting at $190

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.