engine overheats at 10 minutes of running

Asked by Nov 02, 2015 at 05:27 PM about the 1971 FIAT 124 Spider

Question type: Maintenance & Repair

I have a 1971 Spider 1600cc engine that all of a sudden starting
overheating. I start it and run it about every 2 months. It has run fine for 11
years. Now, all of a sudden without anything being changed, it overheats
into the overflow tank in 10 minutes, while driving or sitting. Like another
poster on this site with similar problem, I've replaced: new radiator, water
pump, external thermostat, radiator cap, & fan switch. I've  flushed the
coolant system & refilled with new antifreeze. (filled it very slowly as
prescribed in manual). I jumped the fan motor wires to make sure that it
works. Coolant system pressure test OK. Head gasket & timing OK. Tested
new thermostat in a pan on stove. It's OK. I removed thermostat & hooked
up hose to bottom of radiator. It still overheats before the bottom of radiator  
begins to get warm. I'm ready to shoot this car!  Can anyone save me?

4 Answers

96,495

Well you have eliminated just about everything! It sounds like maybe the water pump is not working some how. Since you eliminated everything else perhaps taking the water pump out and making sure the impeller is still attached to the shaft would be something worth trying. Good luck!

I would retest the external thermostat. I recently replaced mine and began to have overheating problems. I put the new thermostat in a sauce pan on the stove and found it wouldn't open until the water was rapidly boiling. Too late. I put the old thermostat which was still functioning back in and the overheating problem went away.

65

Could be that the radiator fluid got pretty low and you had to add alot of coolant then failed to bleed off the air adequately. My Spider 2000's system was REALLY difficult to bleed. I had to try several methods suggested by fellow owners before I was successful. Some Fiat shop manuals go so far as to suggest drilling a small hole in the metal of the thermostat to allow proper bleeding off of air.

10

I have the same problem. I replaced the radiator,thermostat,fan,and water pump. Bled the air 3 times,It still gets hot after about 5 minutes.It has an electric fan.

1 of 1 people found this helpful.

Your Answer

124 Spider

Looking for a Used 124 Spider in your area?

CarGurus has 281 nationwide 124 Spider listings starting at $27,994.

Postal Code:

FIAT 124 Spider Experts

  • #1
    jamnblues
    Reputation
    90
  • #2
    F_O_R
    Reputation
    50
  • #2
    Rowefast
    Reputation
    50
View All

Related Models For Sale

Used FIAT 500
65 Great Deals out of 706 listings starting at $3,985
Used Ford Mustang
3 Great Deals out of 987 listings starting at $3,900
Used Chevrolet Corvette
512 listings starting at $9,900
Used Chevrolet Camaro
978 listings starting at $11,965
Used Dodge Challenger
679 listings starting at $10,995
Used Dodge Charger
69 Great Deals out of 740 listings starting at $2,950

Used Cars For Sale

2018 FIAT 124 Spider For Sale
43 listings starting at $36,990
2017 FIAT 124 Spider For Sale
237 listings starting at $27,994

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use.